[. . . ] use and maintenance aprilia F=HJ & % MOTO' 6 5 Motó 6. 5 © 1996 aprilia s. p. a. - Noale (VE) This manual is to be considered an integral part of the vehicle, which must be delivered complete with it also in case of resale. reserves the right to modify its models at any time, without prejudice to the main characteristics here described. All rights as to electronic storage, reproduction and total or partial adaptation, with any means, are reserved for all Countries. [. . . ] Uneven roads, rails, manhole covers, indications painted on the road surface, building site metal plates become rather slippery by rain. For this reason all these obstacles have to be carefully avoided, driving smoothly and bending the motorcycle as little as possible. Always use the turn indicators timely when you intend to change lane or direction, avoiding shrp and dangerous movements. 31 5811, 1*, 1 The running-in of the engine is primary to ensure its working life and its correct functioning. If possible, drive on hill roads and/or roads with many bends, so that the engine, the suspensions and the brakes undergo a more effective running-in. Keep to the following indications: x Do not open the throttle suddenly and completely if the speed is low, both during and after the running-in. Remember: 1 mi = 1, 6 km 1 km = 0, 625 mi x After the first 1000 kilometres, carry out the checking operations indicated in the Periodic maintenance chart, see p. 37 (PERIODIC MAINTENANCE CHART), in order to avoid hurting yourself or other people and/or damaging the vehicle. x x Between the first 1000 and 2000 km drive more briskly, change speed and use the maximum acceleration only for a few seconds, in order to ensure better coupling of the components subject to wear; never exceed 5500 rpm (see table). After the first 2000 km you can expect better performance from the engine, in any case without exceeding 6250 rpm. If you have covered that number of kilometres without making long trips, follow the indications given for running-in up to 4000 km. MAXIMUM RECOMMENDED SPEEDS FOR RUNNING-IN mph Ratio Miles covered 4th 5th 1st 2nd 3rd 0 - 310 310 -625 625 - 1250 over the 1250 18 23 25 29 29 36 40 45 39 48 53 60 48 61 67 75 58 72 80 90 x x During the first 100 km, put on the brakes with caution, avoiding sharp and prolonged brakings. This ensures a correct settlement of the friction material on the brake disc pads. Between the first 500 and 1000 km, never exceed 5000 rpm (see table). rpm 4000 5000 5500 6250 32 To park: x Shift the gears to the neutral (green warning light " " on). 23 67233, 1* $1' 3$5. , 1* )LJ  68**(67, 216 72 35(9(17 7+()7 NEVER leave the ignition key in the block and always use the steering lock. Park the vehicle in a safe place, possibly in a garage or a protected place. Make sure that all documents are in order and the road tax has been paid. Write down your personal data and telephone number in the space provided in this manual, to facilitate the identification of the owner in case of finding after theft. Very often stolen vehicles are identified thanks to the data written on the use/maintenance manual. To stop the vehicle: x Release the throttle grip, stop the vehicle by gradually putting on both brakes and shifting down according to the speed of the vehicle. x Disengage the clutch before the vehicle has completely stopped, in order to prevent the engine from stalling. Park the vehicle on firm and flat ground, to prevent it from falling down. Make sure that the vehicle and especially its red-hot parts do not represent a danger for persons and children. Do not leave the vehicle unattended when the engine is on or the key is inserted into the ignition block. Do not seat on the vehicle when the prop stand is down. 33 The vehicle is made up of not edible parts. Never bite, suck, chew or swallow any part of the vehicle for any reason. If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations reversing the order. Ordinary maintenance operations can be carried out by the user, but sometimes a basic knowledge of mechanics and specific tools are required. If you need assistance or technical advice consult your aprilia Official Dealer, who can ensure you quick and careful servicing. [. . . ] 1, 8 bar (Drive with passenger 1, 8 bar) Rear. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130/90 68 H Inflation pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1, 9 bar (Drive with passenger 2, 2 bar) Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . NIPPONDENSO - CDI Standard spark plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]