User manual APRILIA ATLANTIC 250 I.E. 10-2006

[. . . ] The terms left and right are referred to the motorcycle when viewed from the riding position. ! WARNINGS - PRECAUTIONS GENERAL ADVICE Before starting the engine, carefully read this manual paying special attention to section SAFE RIDING. Your safety and that of other road users depends as much on your ability to respond to other traffic and unexpected occurrences as on your familiarity with your vehicle, the vehicle»s efficiency and your knowledge of basic SAFE RIDING techniques. Becoming familiar with your vehicle is the key to deal with traffic effectively and safely. First edition: March 2004 Reprint: Disregarding these indications may lead to severe injury or death. WARNING Disregarding these indications may lead to minor injury or vehicle damage. CAUTION Produced and printed by: DECA s. r. l. +39 - 0545 35235 Fax +39 - 0545 32844 E-mail: deca@decaweb. it www. decaweb. it On behalf of: aprilia s. p. a. [. . . ] Using one brake only reduces braking force significantly and may lock a wheel resulting in loss of grip. To stop while riding uphill, close the throttle and simply use the brakes to keep the vehicle steady. Using the engine to keep the vehicle steady may result in the converter overheating. WARNING When approaching a bend, slow down or brake in good time. Use the brakes sparingly when riding downhill, or the brake lining may overheat and impair braking efficiency. When riding on wet or slippery surfaces (such as snow, ice, mud), slow down, avoid harsh braking and do not swerve suddenly to avoid skidding. Uneven road surfaces, rails, inspection covers, painted signals, construction site metal covers become slippery in rainy weather and must be negotiated carefully, smoothly and keeping the vehicle upright. WARNING use and maintenance Atlantic 125/250 33 these checks may lead to personal injury to yourself or third persons, or vehicle damage. Proper engine running-in is essential to preserving engine life and performance over time. Twisty roads and gradients are ideal to break in engine, suspension and brakes effectively. STOPPING If possible, avoid stopping abruptly or slowing down suddenly. Brake progressively and in good time. Release the throttle twistgrip (pos. A) WARNING NOTE Top acceleration and speed are only obtained after covering the first 1000 km (625 mi). Observe the following instructions: and apply the brakes gradually to stop the vehicle. When stopping for a short time, keep at least one brake on. Always signal your intention to change lane or direction in good time using the direction indicators. Before servicing or inspecting the motorcycle: stop the engine and remove the key from the ignition switch; allo w fo r the en gine a nd exh au st system to cool down; where possible, lift the motorcycle using adequate equipment placed on firm and level ground. Be careful of any parts of the engine or exhaust system which may still be hot to the touch in order to avoid scalds or burns. Never put any mechanical parts or other vehicle components in your mouth when you have both hands busy. However, some maintenance operations require specific tools and are best left to experienced mechanics. If you need assistance or technical advice, contact an aprilia Official Dealer for guaranteed accurate, prompt service. We recommend having the vehicle roadtested at the Dea ler afte r rep ai r or servicing. In addition, perform the Pre-ride checks after any maintenance operation, see page 29 (PRE-RIDE CHECKS CHART). WARNING NOTE In most cases, stolen vehicles are identified through the data written on the Owner»s Manual. Unless expressly specified otherwise, motorcycle assemblies are refitted or re-assembled by reversing the removal or dismantling procedure. Wear latex gloves before servicing the vehicle 36 use and maintenance Atlantic 125/250 CAUTION PERIODIC MAINTENANCE CHART OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer (CAN BE CARRIED OUT BY THE USER AS WELL) Components Rear shock absorbers Battery - Battery fluid level Spark plug Carburettor idle rpm Air cleaner Engine oil filter Throttle operation Brake operation Converter grease Brake light switch Coolant Engine oil Transmission oil Beam setting/operation Tyres/inflation pressure Battery terminals tightening Front fork Brake pads wear Post running-in [1000 km (625 mi)] Every 6000 km (3750 mi) or 8 months Every 12000 km (7500 mi) or 16 months !" " every 1000 km (1250 mi): !/every 16 months: " every 1000 km: !/every 6000 km: " every 6000 km: !/every 24000 km: " ! every month: ! !$ = clean; " = replace; # = adjust. Shorten maintenance intervals if you are riding in rainy and dusty conditions or on loose road surfaces. use and maintenance Atlantic 125/250 37 OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer Components Idle mixture Belt, converter rollers and plastic guides Converter belt Steering bearings Wheel bearings Converter cover air filter Secondary air scoop filter Clutch shoes Valve clearance Brake fluid Front fork oil Engine oil filter mesh and magnetic screw Converter rollers and plastic guides Wheels/tyres Nuts and bolts torque Cylinder head nuts torque Brake bleeding Battery terminals tightening Fuel line Post running-in [1000 km (625 mi)] Every 6000 km (3750 mi) or 8 months Every 12000 km (7500 mi) or 16 months ! !$ = clean; " = replace; # = adjust. Shorten maintenance intervals if you are riding in rainy and dusty conditions or on loose road surfaces. (*) To check these components see pages 15-16: TABLE OF INSTRUMENTS AND INDICATORS. 38 use and maintenance Atlantic 125/250 IDENTIFICATION DATA It is a good rule to write down the frame and engine numbers in the space provided in this manual. [. . . ] Sponge off using a car body sponge soaked in a car body shampoo and water solution (2-4% parts of shampoo). Clean the outer parts of the engine with a degreaser, brushes and a cloth. WARNING Before washing the vehicle 1) Empty the glove and helmet compartments. Rinse with water, but do not use a water cleaner (see page 66). CAUTION Wash the vehicle thoroughly before applying silicone wax. Do not wash the vehicle under the sun, especially in the summertime, when the body is still warm. [. . . ]