Detailed instructions for use are in the User's Guide.
[. . . ] 259. 162170
®
THIS GRILL IS FOR OUTDOOR USE ONLY
CAUTION
WARNING Failure to follow all manufacturer's instructions could result in serious personal injury and/or property damage.
!
!
CAUTION
Read and follow all Safety Statements, Assembly instructions, and Use and Care Manual Directions before attempting to assemble and cook.
Customer Service Toll Free 1-800-396-3838 To Installer/Assembler: Leave these instructions with consumer. To Consumer: Keep this manual for future reference.
!
Some parts may contain sharp edges, wear protective gloves if necessary.
Sears, Roebuck and Co. , Hoffman Estates, IL 60179, U. S. A
1
www. sears. com
SP5290B-37
Table of Contents
Limited Warranty
Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Caring for your equipment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-22 Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-24 Cleaning and Maintenance. . . . . . . . . . . . . . . . . . . . . . 25-26 Parts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 Exploded view. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
One Year Full Warranty on Kenmore Grill If this grill is defective in material or worksmanship within one year from the date of purchase, contact Sears at 1-800-4-MY-HOME® to have it repaired free of charge. Additional Full Warranty on Specific Grill Parts For the time periods listed below, Sears will replace the following specific grill parts free of charge if they are defective in material of workmanship: Lifetime on Cast Aluminum Lids and Bottoms Five years from purchase date on Stainless Burners All warranty coverage excludes ignitor batteries and any grill part paint loss or rusting which are either expendable parts that can wear out from normal use in less than a year, or are conditions that can be the result of normal use, accident or improper maintenance. All warranty coverage is void if this grill is used for commercial or rental purposes. [. . . ] Attach the two wires from the cross lighter as shown to small terminals on ignitor module as shown.
Attach two wires from console assembly to two large terminals as shown.
Correct
Incorrect
NOTE: Use one of the supplied plastic ties to bundle the two large terminal wires together, and one to bundle the four small terminal wires together.
. After wiring ignitor module ensure that all burner knobs are in the off position before installing the battery. Snap ignitor module tabs into into holes on back left side of front panel as shwon. The plastic mounting tabs on the ignitor "hook" into the mounting holes and are not designed to be repeatedly removed and re-installed. Connect regulator with tank valve.
.
CAUTION
!
Be sure that hose assembly does not contact the base casting or any other parts which will get hot.
22
OPERATION Warning: Before proceeding with the following steps, ensure you WARNING have read the L. P. Gas Cylinder hose and Regulator sections of this Assembly and Operation Manual. If burner fails to light, refer to the Troubleshooting Guide to determine cause and solution. Once it is lit, push in and turn right burner knob to high.
!
Fig. 9
SIDE BURNER
LIGHTING
Prior to lighting your grill, visually check all hoses before each use for nicks, cracking, abrasions or cuts. A replacement hose and regulator is required (see `PARTS LIST' in back of book).
Middle Burner Left Burner Right Burner
1. If burner does not light immediately (within four seconds), turn the burner control knob off, and wait 5 minutes to clear the gas. If burner still fails to light, refer to the Troubleshooting Guide to determine cause and solution, or try the Match Lighting Procedure above.
USING THE AUTO IGNITOR
IMPORTANT Fig. HIGH · Do not lean over the grill LOW when lighting the burner. 8 · Visually check the flames every time you light your grill (Figure 8). If the flame is abnormally small or smokey yellow -- shut off the grill and check the venturi tubes for blockage (see Figure 11 on pg. On grills with Three burners, the right control knob operates the right burner, the left knob operates the left burner, and the center knob operates the center burner.
1. You should hear a "clicking sound" indicating your electronic ignition is activated. If burner does not light immediately (within four seconds), turn the burner control knob off, and wait 5 minutes to clear the gas. Repeat steps 1 to 5, if burner fails to light, refer to the Troubleshooting Guide to determine cause and solution, or try the Match Lighting Procedure above. Place an ignited lighter or lit match near the ports, approximately 1/2" (1. 25 cm) from burner. If it does not, extinguish the lighter or match, turn the control knob off, and wait 5 minutes for the gas to clear. If burner still fails to light, refer to the Troubleshooting Guide to determine the cause and solution.
MATCH LIGHTING PROCEDURE
USING THE AUTO IGNITOR
Read these instructions before igniting. [. . . ] When the cylinder is disconnected from the grill, ensure the cylinder valve safety cap is firmly in place. After a period of storage or non-use, a leak test should be performed and the burner venturis cleaned prior to use.
COOKING SYSTEM:
To clean your Heat Distribution Plate scrape it with a brass bristle brush; clean using soap and water, then rinse and dry. DO NOT ALLOW EXCESSIVE GREASE OR OTHER RESIDUE TO BUILD UP ON YOUR COOKING SYSTEM AS A FIRE MAY RESULT.
SIDE SHELVES:
Metal Shelves: Use any household cleaner, except those containing acid or mineral spirits. Plastic Shelves and Panels: Clean with dish washing liquid, then wipe dry. [. . . ]