User manual HUSQVARNA UTILITY VEHICLEL

[. . . ] 2007 Utility Vehicles Electric and Gasoline Owner’s Manual HUV4210-G HUV4210-E HUV4210-GXP HUV4210-EXP NOTICE The Husqvarna warranty statements and California Emission Control Warranty Statement appear on the last pages of this manual. Please complete and return the warranty registration card included in this manual. Husqvarna is not liable for errors in this manual or for incidental or consequential damages that result from the use of the material in this manual. This manual contains proprietary information that is protected by copyright. [. . . ] Crank the engine until fuel is pumped into the carburetor and fuel lines and the engine starts. NOTE: Due to the oil added to the engine in preparation for storage, engine may smoke excessively for a short time when it is run for the first time after storage. 2007 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 29 Maintenance MAINTENANCE See General Warnings on page 9. To ensure trouble-free vehicle performance, it is very important to follow an established preventive maintenance program. Regular and consistent vehicle maintenance can prevent vehicle downtime and expensive repairs that can result from neglect. Use the Pre-Operation and Daily Safety Checklist on page 19 and the following Periodic Service Schedules and Periodic Lubrication Schedules to keep the vehicle in proper working condition. Any vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent further damage to the vehicle and avoid the possibility of injury due to unsafe conditions. Contact your local Husqvarna distributor/dealer to perform all repairs and semiannual and annual periodic service. ý WARNING • If any problems are found during scheduled inspection or service, do not operate the vehicle until repairs are made. Failure to make necessary repairs could result in fire, property damage, severe personal injury, or death. • Only trained technicians should service or repair the vehicle or battery charger. Anyone doing even simple repairs or service should have knowledge and experience in electrical and mechanical repair. The appropriate instructions must be used when performing maintenance, service, or accessory installation. • To avoid unintentionally starting the vehicle, disconnect the batteries as shown (Figure 2, Page 11). • After disconnecting the batteries, wait 90 seconds for the controller capacitors to discharge. Gasoline vehicles only: • Moving parts: Do not attempt to service gasoline vehicle while the engine is running. • Turn the fuel shut-off valve to the closed (OFF) position (Figure 16, Page 28). • To avoid unintentionally starting the vehicle, before servicing always disconnect the battery, negative (–) cable first (Figure 1, Page 11) and disconnect the spark plug wire from the spark plug. • Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting batteries or other electrical wiring. Never allow a positive wire to touch the vehicle frame, engine, or other metal component. Page 30 2007 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Periodic Service Schedules PERIODIC SERVICE SCHEDULES See General Warnings on page 9. ý WARNING • Service, repairs, and adjustments must be made per instructions in the maintenance and service manual. NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance procedure should be performed more often than recommended in the periodic service and lubrication schedules. Both the Periodic Service Schedule and Periodic Lubrication Schedule must be followed to keep vehicle in optimum operating condition. 2007 Husqvarna 4210-G, 4210-E, 4210-GXP, and 4210-EXP Owner’s Manual Page 31 Periodic Service Schedules PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES REGULAR INTERVAL Daily service by owner Weekly service by owner Monthly service by owner or trained technician SERVICE Batteries Batteries Batteries Charge batteries (after each use only). Wash battery tops and clean terminals with baking soda/water solution. [. . . ] The use of any non-exempted add-on or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims. HUSQVARNA will not be liable to warrant failures of warranted parts caused by the use of a non-exempted add-on or modified part. *HUSQVARNA, its authorized dealers, or a service agency approved by HUSQVARNA. ITEMS COVERED BY THIS WARRANTY: The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from such warranty coverage if HUSQVARNA demonstrates that the engine or equipment has been abused, neglected, or improperly maintained, and that such abuse, neglect, or improper maintenance was the direct cause of the need for repair or replacement of the part. That notwithstanding, any adjustment of a component that has a factory installed, and properly operating, adjustment limiting device is still eligible for warranty coverage. [. . . ]